SACRAMENTO (CBS / AP) — One passenger said it was a “real quick blast, like a gun.” Another called it “pandemonium.” Still another described watching a flight attendant and another passenger pass out, their heads striking the seats in front of them as they lost consciousness.
Federal officials said it was a “fuselage rupture”—a large hole on the top of the Boeing 737 — that led to a loss of cabin pressure and a terrifying descent from 36,000 feet to an emergency landing at a military base in the Arizona desert.
No serious injuries were reported among the 118 aboard, according to Southwest Airlines, and the FBI said it was a “mechanical failure,” not an act of terror or other foul play. The cause of the hole was not immediately known.
Passenger Brenda Reese said Flight 812 had just left Phoenix Sky Harbor International Airport for Sacramento, when a “gunshot-like sound” woke her up. She said oxygen masks dropped for passengers and flight attendants as the plane dove.
Ian Gregor, a Federal Aviation Administration spokesman in Los Angeles, said the pilot “made a rapid, controlled descent from 36,000 feet to 11,000 feet altitude.”
Don Nelson, who was seated one row from the rupture, said it took about four noisy minutes for the plane to dip to less than 10,000 feet, which made him “lightheaded.”
During the rapid descent, “people were dropping,” said Christine Ziegler, a 44-year-old project manager from Sacramento who watched as a crew member and a fellow passenger nearby faint, hitting their heads on the seats in front of them.
Larry Downey, who was seated directly below the hole when it opened, told Phoenix TV station KPNX that “it was pandemonium.”
“You could look out and see blue sky,” he said.
Joshua Hardwicke said he was awakened by a “sound like you shook up a pop can and dropped on the ground. It was like a firecracker.”
The 24-year-old motorcycle technician was seated seven rows from the hole, which Reese described as “at the top of the plane, right up above where you store your luggage.”
“The panel’s not completely off,” she told The Associated Press. “It’s like ripped down, but you can see completely outside… When you look up through the panel, you can see the sky.”
Cellphone photographs provided by Reese showed a panel hanging open in a section above the plane’s middle aisle, with a hole of about six feet long. Nelson compared the noise to a gun, “a real quick blast,” and said when the hole “first blew out, you could tell there was an oxygen deficiency.”
The plane landed at a military base in Yuma without any injuries reported, except for a flight attendant who was slightly injured, according to the airline. Reese said the crewmember fell and injured his nose, and that some people passed out “because they weren’t getting the oxygen.”
The National Transportation Safety Board said an “in-flight fuselage rupture” led to the drop in cabin pressure aboard the 15-year-old plane. A similar incident on a Southwest plane to Baltimore in July 2009 also forced an emergency landing when a foot-long hole opened in the cabin.
Four months earlier, the Dallas-based airline had agreed to pay $7.5 million to settle charges that it operated planes that had missed required safety inspections for cracks in the fuselage. The airline, which flies Boeing 737s, inspected nearly 200 of its planes back then, found no cracks and put them back in the sky.
Julie O’Donnell, an aviation safety spokeswoman for Seattle-based Boeing Commercial Airplanes, confirmed “a hole in the fuselage and a depressurization event” in the latest incident but declined to speculate on what caused it.
Reese said there was “no real panic” among the passengers, who applauded the pilot after he emerged from the cockpit following the emergency landing at Yuma Marine Corps Air Station/International Airport, some 150 miles southwest of Phoenix and about 40 minutes after takeoff from Sky Harbor.
“It was unreal. Everybody was like they were high school chums,” Ziegler said, describing a scene in which passengers comforted and hugged each other after the plane was on the ground. Southwest sent another airliner to take them to Sacramento later Friday.
“I fly a lot. This is the first time I ever had something like this happen,” said Reese, a 37-year-old single mother of three who is vice president for a clinical research organization. “I just want to get home and hold my kids.”
Gregor said an FAA inspector from Phoenix was en route to Yuma.
The NTSB said it also was sending a crew to Yuma.
Holes in aircrafts can be caused by metal fatigue or lightning. The National Weather Service said the weather was clear from the Phoenix area to the California border on Friday afternoon.
In 1988, cracks caused part of the roof of an Aloha Airlines Boeing 737 to peel open while the jet flew from Hilo to Honolulu. A flight attendant was sucked out of the plane and plunged to her death, and dozens of passengers were injured.
(Copyright 2011 by CBS San Francisco. All Rights Reserved. This material may not be published, broadcast, rewritten, or redistributed. Wire services may have contributed to this report.)